The effects of silver carp (Hypophthalmichthys molitrix) protein hydrolysate replacement with egg on stability and sensory properties of mayonnaise

Document Type : (original research)

Authors

1 Department of Fisheries, Faculty of Animal Sciences and Fisheries . Sari Agricultural Sciences and Natural Resources University, Sari, Iran

2 Department of Fisheries, Faculty of Animal science and Fisheries, Sari Agricultural Sciences and Natural Resources University, Sari, Iran

3 Department of Fisheries, Faculty of Animal Sciences and Fisheries. Sari Agricultural Sciences and Natural Resources University, Sari, Iran

4 Caspian Sea Ecology Research Institute, Iranian Fisheries Science Research Institute, Agricultural Research Education and Extension Organization, Sari, Iran

Abstract

Mayonnaise is oil- in water emulsion that used as a good choice for consumers because of its favorable texture and good taste. In this research, the effect of egg replacement by silver carp (Hypophthalmicthys molitrix) protein hydrolysate on chemical composition, thermal-mechanical stability and sensory properties of produced mayonnaise was investigated in 1394. For this purpose, the silver carp protein hydrolysate was produced by using protamex enzyme (1.5%), then was used in different levels of 0, 25, 50, 75 and 100% as an egg replacer. The results of chemical composition of treatments showed that by increasing the amount of silver carp protein hydrolysate in the prepared mayonnaise, crude protein and ash content significantly increased compared to the control (p < 0.05) and fat and moisture content significantly decreased compared to the control (p < 0.05). Also, the results showed higher emulsion stability of produced mayonnaise containing fish protein hydrolysate at -20 and 50˚C compared to the control (p < 0.05). Sensory assessment declared that the factor of flavor in different treatments except 50% replacement didn’t have any significant differences and other sensory factors (odour, texture, color and overall acceptability) didn’t show significant differences among treatments (P>0.05). Overall, it is concluded that the mayonnaise egg can be replaced by fish protein hydrolysate with similar properties and even resulted to better properties than general mayonnaise, occasionally.

Keywords

Main Subjects

References

  1. Abu Ghoush M.; Samhouri, M.; Al-Holy, M. and Herald, T., 2008. Formulation and fuzzy modeling of emulsion stability and viscosity of a gum-protein emulsifier in a model mayonnaise system. Journal of Food Engineering. Vol. 84, No. 8, pp: 348-357.
  2. Anton, M.; Martinet, V.; Dalgararrondo, M.; Beaumal, V.; David-Briand, E. and Rabesona, H., 2003. Chemical and structural characterisation of low-density lipoproteins purified from hen egg yolk. Food Chemistry. Vol. 83, pp: 175-183.
  3. AOAC. 2005. Officialmethods of analysis of the association of official analytical chemists Arlington, Association of official analytical chemists.
  4. Aspmo, S.I.; Horn, S.J. and Heijsink, V.G., 2005.  Enzymatic hydrolysis of Atlantic cod (Gadus morhua L.) viscera. Process Biochemistry. Vol. 40, pp: 1957-1966.
  5. Binsi, P.K.; Natasha, N.; Sarkar, P.C.; Ashraf, P.M.; George, N. and Ravishankar, C.N., 2017. Structural, functional and in vitro digestion characteristics of spray dried fish roe powder stabilized with gum arabic. Food Chemistry. Vol. 221, pp: 1698-1708.
  6. Elavarasan, K.; Naveen Kumar, V. and Shamasundar, B.A., 2014. Antioxidant and functional properties of fish protein hydrolysates from fresh water carp (Catla catla) as influenced by the nature of enzyme. Journal of Food Processing and Preservation. Vol. 38, No. 3, pp: 1207-1214.
  7. Elenice Souza, G.; Maria Louisa, S.; Jane Martha, M.; Katia Setsuko, K.; Adina Celia Borazon, D. and Elaine, G., 2016. Fresh pasta enrichment with protein concentrate of tilapia: nutritional and sensory characteristics Food Science and Technology (Campinas). Vol. 36, No. 1, pp: 76-82.
  8. FAO. 2019. Fishery statistical collection. Food and Agriculture Organization of the United Nations. 107 p.
  9. Gajanan, P.G.; Elavarasan, K. and Shamasundar, B.A., 2016. Bioactive and functional properties of protein hydrolysates from fish frame processing waste using plant proteases. Environmental Science and Pollution Research. Vol. 23, No. 24, pp: 24901-24911.
  10. Harnedy, P.A. and FitzGerald, R.J., 2012. Bioactive peptides from marine processing waste and shellfish: A review. Journal of Functional Foods. Vol. 4, No. 1, pp: 6-24.
  11. Herald, T.J.; Abugoush, M. and Aramoun, F., 2009. Physical and sensory properties of egg yolk and egg yolk substitutes in a model mayonnaise system. Journal of Texture Studies. Vol. 40, pp: 692-709.
  12. Hoyle,  N.T.  and  Merritte,  J.H., 1994.  Qyality of Fish Protein Hydrolysates from Herring (Clupea harengus). Journal Of Food Science. Vol. 59, pp: 76-79.
  13. Kim, S.K. and Wijesekara, I., 2010. Development and biological activities of marine derived bioactive peptides: A review. Journal of Functional Foods. Vol. 2, No. 1, pp: 1-9.
  14. Klampong, V.; Benjakul, S.; Kantachote, D. and Shahidi, F., 2007. Antioxidative activity and functional properties of protein hydrolysate of yellow stripe trevally as influenced by the degree of hydrolysis and enzyme type. Food Chemistry. Vol. 102, No. 4, pp: 1317-1327.
  15. Kristinsson, H.G. and Rasco, B.A., 2000a. Biochemical and functional properties of Atlantic salmon (Salmo salar) muscle proteins hydrolyzed with various alkaline proteases. Journal of Agricultural and Food Chemistry. Vol. 48, pp:657-666.
  16. Kristinsson, H.G. and Rasco, B.A., 2000b. Fish protein hydrolysates: production, biochemical, and functional properties. Critical Reviews in Food Science and Nutrition. Vol. 40, pp: 43-81.
  17. Kristinsson, H.G. and Rasco, B.A., 2000c. Hydrolysis of salmon muscle proteins by an enzyme mixture extracted from Atlantic salmon (Salmo salar) pyloric caeca. Journal of Food Biochemistry. Vol. 24, pp: 177-187.
  18. Liu, H.; Xu, X.M. and Guo, Sh.D., 2007. Rheological, texture and sensory properties of low-fat mayonnaise with different fat mimetics. LWT- Food Science and Technology. Vol. 40, pp: 946-954.
  19. Mun,  S.;  Kim,  Y.L.;  Kang,  C.G.;  Park,  K.H.;  Shim,  J.Y.  and  KIim, Y.R., 2009. Development of reduced-fat mayonnaise using 4GTase-modified rice starch and xanthan gum. International Journal of Biological Macromolecules. Vol.  44, pp: 400-407.
  20. Ngo, D.H.; Wijesekara, I.; VO, T.S.; Van Ta, Q. and Kim, S.K., 2011. Marine food derived functional ingredients as potential antioxidants in the food industry: an overview. Food Research International. Vol. 44, No. 2, pp: 523-529.
  21. Nikzade,  V.;  Tehrani,  M.M.  and  Saadatmand-Tarzjan,  M., 2012. Optimization of low-cholesterolelow-fat mayonnaise formulation: Effect of using soy milk and some stabilizer by a mixture design approach. Food Hydrocolloids. Vol. 28, pp: 344-352.
  22. Nir, L.; Feldman, L.; Aserin, A. and Garti, N., 1994. Surface properties and emulsification behavior of denatured soy protein.Journal of Food Science. Vol. 59, No. 3, pp: 606-607.
  23. Ovissipour, M.; Abedian kenari, A.; Motamedzadegan, A.; Rasco, B.; Safari, R. and Shahiri, H., 2009a. The effect of enzymatic hydrolysis time and temperature on the properties of protein hydrolysates from Persian sturgeon (Acipenser persicus) viscera. Food Chemistry. Vol. 115, pp: 238-242.
  24. Ovissipour, M.; Safari,  R.; Motamedzadegan, A. and Shabanpour, B., 2009b. Chemical and Biochemical Hydrolysis of Persian Sturgeon (Acipenser persicus) Visceral Protein. Food and Bioprocess Technology. Vol. 5, pp: 460-465.
  25. Ovissipour, M.; Safari, R.; Motamedzadegan, A.; Rasco, B.; Pourgholam, R.; Mohagheghi, E. and Mola, A.E., 2009c. Use of hydrolysates from yellowfin tuna Thunnus albacares fisheries by-product as a nitrogen source for bacteria growth media. International Aquatic Research. Vol. 1, pp: 73-77.
  26. Rehman, S.A.; Akhter, S.; Khan, S.H. and Anjum, M.A., 2016. A comparative study on quality, proximate composition and cholesterol content of eggs and meat in Fayoumi and commercial White Leghorn chickens. Cognet Food and Agriculture. Vol. 2, pp: 1-7.
  27. Sathivel, S.; Bechtel,  P.J.; Babbitt, J.K.; Prinyawiwatule, W. and Patterson, M., 2005. Functional, Nutritional, and Rheological Properties of Protein Powders from Arrowtooth Flounder and their Application in Mayonnaise. Journal  of  Food  Science, Vol. 70, pp: 57-63.
  28. Sathivel, S.; Yin, H.; Bechitel, P.J. and King, J.M., 2009. Physical and nutritional properties of catfish roe spray dried protein powder and its application in an emulsion system. Journal of Food Engineering. Vol. 95, pp: 76-81.
  29. Šližyte, R.; Dauksas, E.; Falch, E.; Storro, I. and Rustad, T., 2005. Yield and composition of different fractions obtained after enzymatic hydrolysis of cod (Gadus morhua) by-products. Process Biochemistry. Vol. 40, pp: 1415-1424.
  30. Souissi, N.; Bougatef, A.; Triki-Ellouz, Y. and Nasri, M., 2007. Biochemical and functional properties of sardinella (Sardinella aurita) by-product hydrolysates. Food Technology and Biotechnology. Vol. 45, pp: 187-194.
  31. Taheri, A.; Anvar, S.A.A.; Ahari, H. and Fogliano, V., 2012. Comparison the functional properties of protein hydrolysates from poultry byproducts and rainbow trout (Onchorhynchus mykiss) viscera. Iranian Journal of Fisheries Science. Vol. 12, No. 1, pp: 154-169.
  32. Unnikrishnan, P.; Puthenveetil Kizhakkethil, B.: Anant Jadhav, M.; Sivam, V.; Muhamed Ashraf, P.; Ninan, G. and Aliyamveetil Abubacker, Z., 2019. Protein hydrolysate from yellowfin tuna red meat as fortifying and stabilizing agent in mayonnaise. Journal of Food Science and Technology. Vol. 57, pp: 413-425.
  33. Vázquez, J.A.; Rodríguez-Amado, I.; Montemayor, M.I.; Fraguas, J.; González, M.P. and Murado, M.A., 2013. Chondroitin Sulfate, Hyaluronic Acid and Chitin/Chitosan Production Using Marine Waste Sources: Characteristics, Applications and Eco-Friendly Processes: A Review. Marine Drugs. Vol. 11, No. 3, pp; 747-774.
  34. Venugopal, V. and Shahidi, F., 1996. Structure and composition of fish muscle. Journal of Food Technology and Enzyme Engineering Division. Vol. 12, pp: 175-197.
  35. Worrasinchai, S.; Suphantharika, M.; Pinjai, S. and Jamnong, P., 2006. β-Glucan prepared from spent brewer’s yeast as a fat replacer in mayonnaise. Food Hydrocolloids. Vol. 20, pp: 68-78.
Journal of Animal Environment
Volume 13, Issue 1
May 2021
Pages 337-346

Files

Share

How to cite

Statistics